Page 80 - Manual_PGA_RZR_2020

FOR THE LIFE

OF YOUR RIDE

AIR FILTERS
MAINTENANCE Critical to engine performance and
reliability. A clogged air filter can restrict
TIP air flow to the engine leading to reduced
engine performance. Dirt and debris
ingestion can damage the engine leading
to reduced engine life or catastrophic
BREAK-IN PERIOD failure. Polaris recommends changing
the vehicle’s air filter at the specified
The break-in period for your new intervals outlined in the owner’s manual,
RZR is the first 25 hours of which may be shorter if your vehicle is
subject to severe conditions.
operation, or the time it takes to
use the first two tanks of fuel. No
single action on your part is as BRAKE PADS
important as a proper break-in
period. Careful treatment of a new Check your brakes if you are close to the
engine will result in more efficient recommended service interval, hear
grinding when applying the brakes, your
performance and longer life for the vehicle is taking longer to stop or if you
engine. Perform the listed have to apply more pressure to your
procedures carefully. pedal to engage the brakes. Check the
brake discs for signs of cracks,
excessive corrosion or warping.
NOTICE: Excessive heat build-up during the first If the brake pads are contaminated with
three hours of operation will damage oils or grease (petroleum products), brake
close-fitted engine parts. Do not operate at full
throttle or high speeds for extended periods pads have to be discarded and replaced.
during the first three hours of use. Discs need to be cleaned with brake
cleaner or alcohol based cleaner only.
HALF SHAFT
Extreme elements can contribute to
axle failure when grease escapes the
joint. This usually occurs if the CV boot
becomes compromised. Full
replacement or part specific available.

MAINTENANCE SCHEDULE

25 HRS/400 km 50 HRS/800 km 100 HRS/1600 km 150 HRS/2400 km 200 HRS/3200 km
BREAK-IN 6 12 18 24
MAINTENANCE
MONTHS MONTHS MONTHS MONTHS
ENGINE OIL: EXHAUST SYSTEM: ENGINE OIL: ENGINE OIL:
CHANGE INSPECT & CLEAN CHANGE CHANGE
INSPECT FOR LEAKAGE OR
GENERAL CARBON BUILD UP AT JOINTS DRIVE BELT: BATTERY:
LUBRICATION: INSPECT & CLEAN SCREEN TYPE INSPECT & ADJUST TEST, CLEAN, &
ALL FITTINGS, PIVOTS, SPARK ARRESTOR REPLACE AS NEEDED CHECK FLUID LEVEL
CABLES, ETC. REPLACE AS NEEDED
GENERAL TRANSMISSION
AIR FILTER: LUBRICATION: FLUID: DRIVE BELT:
INSPECT & CLEAN ALL FITTINGS, PIVOTS, CHANGE INSPECT & ADJUST
REPLACE AS NEEDED CABLES, ETC. REPLACE AS NEEDED
EXHAUST SYSTEM:
EXHAUST SYSTEM: DRIVE BELT: INSPECT & CLEAN TIRES:
INSPECT & CLEAN INSPECT & ADJUST INSPECT FOR LEAKAGE OR INSPECT CONDITION
INSPECT FOR LEAKAGE OR CARBON BUILD UP AT JOINTS & PRESSURE
CARBON BUILD UP AT JOINTS REPLACE AS NEEDED
INSPECT & CLEAN SCREEN
INSPECT & CLEAN SCREEN TYPE SPARK ARRESTOR EXHAUST SYSTEM:
TYPE SPARK ARRESTOR INSPECT & CLEAN
INSPECT FOR LEAKAGE OR
CARBON BUILD UP AT JOINTS

INSPECT & CLEAN SCREEN
78 TYPE SPARK ARRESTOR
78